PTFE中空纤维膜直接接触式膜蒸馏过程抗污染性能

通过研究不同原水对直接接触式膜蒸馏过程的影响,考察了聚四氟乙烯膜对无机盐、胶体和有机物的抗污染性能。研究表明,在35 g/L氯化钠溶液的4倍浓缩过程中,PTFE膜的相对通量降低至0.72;与碳酸钙饱和溶液的浓缩过程相比,由于溶解度的差异,硫酸钙饱和溶液浓缩过程中晶体析出量更多,通量衰减也更为严重;浓缩硅溶胶时,二氧化硅单体聚合并吸附于膜面从而引起膜通量的衰减,随着浓缩的进行,料液p H值不断上升,使得胶体体系愈加稳定,浓缩到2.6倍后相对通量没有随着浓缩倍数的增加出现明显下降,维持在0.73左右;腐殖酸在水中表现出的亲水性和电负性使其难以在具有较强疏水性的聚四氟乙烯膜表面上形成滤饼层,浓缩过程中相对通量始终保持在0.9以上。     

阳膜电解法处理含镍废水

采用阳膜电解法处理低浓度含镍废水。考察了电解质种类及其加入量、电解电流、电流密度、搅拌转速、电解温度和电解时间等对电解效果的影响。实验结果表明,在电解质NaCl加入量为2.5 g/L、电解电流为0.10A、电流密度为150 A/m~2、搅拌转速为800 r/min、电解温度为35℃、电解时间为8 h的最佳条件下,处理Ni2+质量浓度为2 g/L的含镍废水,镍析出率达到95.16%,电流效率为86.87%,单位质量能耗为5 254 k W·h/t。     

In vitro evaluation of the mutagenic and cytostatic effect of Tamaron,Lannate and Manzate alone and in mixture

Pesticides are often used in agriculture, especially in floriculture. They are frequently applied in binary or ternary mixtures. Nevertheless, their impact on the genetic material has been scarcely explored. In this study, the mutagenic and cytostatic effect of three widely used pesticides, alone and combined, were analyzed. Briefly, lymphocytes cultures were obtained from peripheral blood samples of five healthy donors to determine the sister chromatid exchange and the replicative index (RI). Then, lymphocytes were exposed to Tamaron (100 ppm), Lannate (200 ppm) and Manzate (300 ppm) alone and combined. For the binary mixtures, the concentrations used were 50 ppm of Tamaron, 100 ppm of Lannate and 150 ppm of Manzate. For the ternary mixtures the following concentrations were used: Tamaron (33 ppm), Lannate (70 ppm) and Manzate (100 ppm). Finally, differential staining was performed. It was found that the frequency of SCE/cell showed a significant difference (P ≤ 0.05) between the control (2.66) and the individual treatments of Tamaron (4.87), Lannate: (5.12) and Manzate (4.23). Also, the values of the SCE in the binary mixture of Tamaron+Lannate (5.57), Tamaron+Manzate (6.06) and Lannate+Manzate (6.22) and the ternary mixture (6.63) were statistically different compared to the control. In the RI there was a significant difference between the control (1.98) and the Manzate (1.87). RI differences were also statistically significant (P ≤ 0.05) in mixtures of Tamaron+Lannate (1.64), Tamaron+Manzate (1.63), Lannate+Manzate (1.69) and total mixture (1.53). Therefore, it is suggested that these pesticides alone and in mixtures have both mutagenic and cytostatic synergistic effect in human lymphocytes in vitro.     

Combined modelled and measured uptakes of arsenic and uranium by Lemna gibba G3 cells

With data from in vitro and in situ investigations, we developed a mathematical model to describe cellular uptake of uranium and arsenic in solution by living Lemna gibba under homeostatic regulation. The model considers the ability of healthy cells to resist accumulation of toxic metal species by regulating physicochemical properties of the cell membrane. In the bulk solution, the ratio of the total amounts of bioavailable metal ions to the metal ions uptake by the cells is very high. Consequently, the main rate-limiting processes of uptake are the biosorption kinetics on both external and internal surfaces at the biological interface, and the transport of the metal ions across the cell membrane. The model prediction correlates well with uptake results from field and microcosm experiments for uranium and arsenic by L. gibba, a model ecotoxicological test organism.     

颗粒物粒径和有机物分子量对超滤膜污染的影响

采用不同孔径和截留分子量的膜对原水进行预过滤,研究不同粒径的颗粒物和不同分子量的有机物对膜污染的影响。结果表明,随着预过滤膜孔径或截留分子量的减小,原水中浊度、CODMn、DOC和UV254的去除率逐渐提高,超滤膜运行的跨膜压力(TMP)比直接过滤原水时降低;经孔径为1.2μm和0.45μm的膜预过滤后,超滤膜运行的TMP仍上升较快,而经过截留分子量为100 kDa及以下膜预过滤后,膜污染比较缓慢。对膜阻力构成分析的结果表明,随着预过滤膜孔径或截留分子量的减小,超滤膜运行过程中的表面饼层阻力逐渐减小,堵孔阻力也有明显降低,但预膜滤不能有效降低膜的吸附阻力。超滤膜表面的扫描电镜观察结果表明,经过截留分子量在100 kDa及以下的膜预过滤后,超滤膜表面比较干净,此时的膜过滤阻力主要来源于吸附和堵孔阻力。     

法库沸石对氨氮的吸附特性和阳离子交互过程

以0.9~2 mm和3.3~4 mm粒径沸石的天然法库沸石作为实验材料,开展了等温吸附实验、动力学实验和阳离子影响实验,探讨了天然沸石对氨氮(NH+4-N)的吸附特性及阳离子交互过程。结果表明,法库沸石对NH+4-N等温吸附线符合Langmuir和Freundlich吸附方程,最大吸附量为10.41 mg/g。吸附动力学过程符合准二级和颗粒内经扩散动力学方程,其吸附NH+4过程为物理吸附和化学吸附过程,并以化学吸附为主。对反应过程中各离子浓度监测发现,沸石中与NH+4发生离子交换的主要是Na+、Ca2+和K+,三者占离子交换总量的99%。共存阳离子在沸石吸附NH+4过程中,Ca2+和Mg2+对吸附过程影响最大,Na+影响最小。     

水中抑制物对定量PCR与膜过滤法检测E.coli的影响

针对水中病原微生物的污染,选择大肠埃希氏菌E.coli作为病原示踪剂,以E.coli染色体上β-葡萄糖醛酸酶uid A目的基因建立了SYBR Green实时荧光定量PCR的检测方法。该定量PCR方法灵敏度高,检测限可达104CFU/L,线性关系良好,相关系数为R2=0.999。研究表明,定量PCR与菌液浓度呈显著正相关R2=0.935。通过人工投加腐殖酸、COD,研究了水中抑制物对定量PCR和膜过滤MF培养法的影响。结果显示,腐殖酸可使E.coli在培养皿上的菌落变小聚集,且显色不明显,当腐殖酸量为20 mg/L时,浓度为50 CFU/100 m L的E.coli完全受到抑制,没有菌落出现。腐殖酸对PCR扩增的抑制作用明显,当腐殖酸浓度增加到10 mg/L,定量PCR检测结果基因拷贝数减少约1 log,增加到20 mg/L定性PCR检测结果为阴性。     

真空膜蒸馏和膜吸收及其集成工艺处理高氨氮废水

采用PP中空纤维膜组件,对VMD(真空膜蒸馏)和MA(膜吸收)脱氨过程进行了研究。考察了料液p H值(9.0~11.0)、料液进口温度(20~50℃)对脱氨效率的影响。研究结果表明,VMD和MA脱除率分别达85%和99%以上。料液p H和料液进口温度对VMD脱氨效果的影响较大,提高料液p H和进口温度可以明显提高VMD的脱氨效率;料液p H对MA的脱氨效率影响较为显著。对2种膜工艺进行了技术集成,利用该集成工艺可达到99.96%以上的氨去除率,出水可达标排放,并且可以有效防止硫酸铵的二次污染。     

膜电容去离子复合电极处理自来水

采用膜电容去离子技术,对镇江自来水进行处理.确定膜电容去离子装置所需的各种材料,设计并制作复合电极单元.将5个复合电极处理单元串联并进行实验,确定能适应市场需求的装置参数,包括内部结构参数和外部运行参数.实验结果表明,当装置的活性炭纤维比表面积为1 600 m2/g,电极间距为1.5 mm,电压为2.0V时,处理效果较好.流量为350 mL/min时复合电极装置的处理效果比100 mL/min差,但是更符合市场需求.一定范围内的温度变化对该装置去除效果的影响很小.将复合电极单元数从5个增至40个后,离子去除率由12.73％增至62.32％.     

聚苯胺修饰电极去除水中高氯酸根

在三电极体系中,研究聚苯胺修饰电极对高氯酸根离子的电化学去除。基于导电高聚物的电控离子交换特性,在其电化学扫描过程中高氯酸根能够掺杂进入到聚苯胺高分子链。在0.10 mol/L Na2SO4(p H 4.0)电解液中电化学循环伏安扫描25 min,2 mg/L高氯酸根的去除率达96.5%;在相同处理时间内,去除率随高氯酸根浓度的增加而明显降低,且溶液p H在3到5的范围内得到最优的去除效果。通过红外光谱和X射线光电子能谱表征高氯酸根掺杂前后的聚苯胺膜,结合循环伏安图的分析提出高氯酸根去除过程中可能的反应机理:高氯酸根作为掺杂离子,随电位的改变在聚苯胺链中迁移。研究表明,基于聚苯胺的电控离子交换特性,可以开发一种绿色高效的高氯酸根去除技术。